Q. H. Wang, H. Wen, Q. S. Wang and J. H. Sun (2012) Inhibiting effect of Al(OH)(3) and Mg(OH)(2) dust on the explosions of methane-air mixtures in closed vessel. Journal/Science China-Technological Sciences 55 1371-1375. [In English]
Web link: http://dx.doi.org/10.1007/s11431-012-4771-3
Keywords: explosion inhibition, explosion pressure, explosion limits, dust, metal, hydroxides, SUPPRESSION, GAS
Abstract: The inhibiting effect of Al(OH)(3) and Mg(OH)(2) dust on explosion of methane-air mixtures was investigated by means of explosion parameter tests in a 20-liter closed vessel. The influences of varying methane concentration and dust concentration on explosion parameters were characterized based on the experimental data to determine the maximum explosion pressure, maximum rate of pressure rise, lower explosion limits and upper explosion limits. The inhibiting mechanisms of these kinds of dust were analyzed as well. The investigations indicate that Al(OH)(3) and Mg(OH)(2) dust can be used as inhibitors to prevent methane explosion, however, their inhibiting effects are less than those of inert gas such as N-2 and CO2 in that their dust can weaken the methane explosion but cannot totally eliminate it. The tests show that all of the explosion parameters with dust additives are strongly dependent on methane/air ratio and dust concentration, and Al(OH)(3) dust has better performance than Mg(OH)(2) dust in inhibiting methane explosion. The average percentage decreases of maximum explosion pressure and maximum rate of pressure rise with Al(OH)(3) dust are 11.08% and 66.15%, respectively. Experiments also showed that there is a special phenomenon when methane explosion is inhibited by Al(OH)(3) and Mg(OH)(2) dust, in which is that during the process of explosion the maximum explosion pressure value first decreases then increases as dust concentration increases. The best dust concentrations to inhibit the explosion are 250 g/m(3) with methane/air ratio at 9.5%, and 200 g/m(3) with methane/air ratio at 7%. It is suggested that water vapor produced by the thermal decomposition of metal hydroxides makes the particles of descending dust combine, resulting in a decrease of the real dust concentration in the vessel. Water vapor also is the major cause of another phenomenon that the LEL curve and the UEL curve never meet with the increase of gas concentration.